深圳市聚力电池有限公司    
       
产品规格书    文件编号  日期 Rev
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18 
       
       
       
  产品规格书     
 圆柱锂离子电池      
  型号:LC 32600  5000mAh     
       
修订记录       
修订  日期 初稿  修订原因  
  2010-4-18 2010-4-18  原始版本  
       
       
  拟制：  批准：          
  签名  签名          
              
              
  日期：  日期：          
              
              
              
              
              
              
              
              
              
   深圳市聚力电池有限公司           
              
产品规格书    文件编号 No.  日期： Rev
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18 
1.0 基本特性     2.0 外形尺寸图  
型号   LC32600A    
外壳材质   镀镍刚壳   Top view 
标称容量（0.2C5A）   5000 mAh    
额定电压   3.70V   19.2mmRef 
最大充电电压   4.2V    
截止放电电压   2.75V    
最大充电电流   1 C5A    Max32.6mm
最大持续放电电流   1.5 C5A    
最大瞬间电流   5 C5A    
电池直径 (Max.)   32.6±0.3 mm    
电池高度 (Max.)   60.3±0.3 mm    
电池重量(Approx.)   126.2g    
内阻（Max, at 1000Hz.）   ≤70 mΩ    (充电态)    Max 60.3mm
"充电方法
(CC/CV) 标准"  快速 0.5 C5A×4hrs    
  标准 0.2 C5A×8hrs.    
操作温度  充电 0℃～60℃（32oF～113oF）    
  放电 “-20℃~75℃（-4oF～140oF）    
  存贮 “-20℃～45℃（-4oF～113oF）    
3.0 特征曲线图       
       
       
       
       
       
       
       
       
       
       
   深圳市聚力电池有限公司           
              
产品规格书    文件编号  日期 Rev       
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18        
4.0 电池性能              
说明：              
若没有特别说明，试验均需在1标准大气压，环境温度20℃±5℃，相对湿度为45％～80％的条件下进行。              
电池在做各项试验前，均需以0.2CA恒流放电至终止电压2.75V。              
4.1电化学性能              
   说明：              
序号 项目 标准  测试方法          
  放电容量/标称容量》100%  在1标准大气压，环境温度20℃±5℃，相对湿度为          
  A）0.2C5A≥100%  45％～80％的条件下进行。电池0.5C标准充电后          
 常温放电 B）0.5C5A≥95%  （以下若没有特别说明，均在此条件下放置，皆按          
1 性能   此充电方式），搁置10Min，分别以0.2C5A、0.5C5A          
    进行放电至下限电压2.75V，循环三次，当有一次          
    达到标准，即达到标准要求（下同）。   
    测量电池的初始状态和0.5C初始容量，   
2 循环性能 容量≥标称容量*80%  0.5C标准充电后以0.5C5A放电至终止电压2.75V搁置   
    15Min，以此模式循环300次，测量电池的最终状态   
    测量电池的初始状态和初始容量，电池标准充电后，   
 常温荷电 剩余容量≥标称容量*85%  开路放置30天，测量电池最终状态；以0.5C5放电   
3 保持 恢复容量≥标称容量*90%  至2.75V，测量电池的剩余容量；0.5C/0.5C   
 能力   测量电池的恢复容量。   
       
    测量电池的初始容量，电池充电至4.2±0.02V后，测   
  0.2C5A放电时间  量电池存储前的初始状态，分别室温贮存3个月、6   
4 贮存性能 贮存3个月的电池≥4.5h；  个月、12个月，测量电池的最终状态，在以0.2C5进行   
  贮存6个月的电池≥4.25h;  放电记录放电时间，然后以0.5C/0.5C循环3次记录   
  贮存12个月的电池4h.  电池的放电时间。   
       
       
              
              
              
   深圳市聚力电池有限公司           
              
产品规格书    文件编号  日期 Rev       
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18        
4.2安全性能              
注意：如果进行下述试验，均需在良好的安全措施保护下，由专业人员进行。否则可能会对实验设备              
和人身造成意外伤害！！！              
序号 项目 标准  测试办法          
 过充 不爆炸、不起火、  电池标准充电，测量电池的初始状态，以3C5A电流          
1 性能 最高温度≤130oC  充电至10.0V，然后转恒压充电至截止电流0.01CC5A          
    时终止，记录过程温度，测量电池的最终状态。          
    测量电池的初始容量，电池标准充电后，测量电池          
2 过放 不起火、不爆炸  初始状态，以0.5C5A进行放电至2.75V，然后用10Ω          
 性能   的电池正负极相连，搁置14天。测量电池的最终状态。   
 常温 不爆炸、不起火、  电池标准充电，测量电池的初始状态，置于防爆玻璃   
3 短路性能 最高温度≤130oC  罩中直接短路其正负极（线路总电阻不大于50mΩ），   
    当电池温度下降到比峰值约低10oC时，结束试验。   
    电池充电后，测量电池的初始状态，置于60±2oC防   
4 高温 不爆炸、不起火  爆箱中，放置3h后直接短路其正负极（线路总电阻不   
 短路性能 最高温度≤130oC  大于50mΩ），试验过程监视电池温度变化，当电池温   
    度下降到比峰值约低10oC时，结束试验。   
    电池标准充电后，测量电池的初始状态，放在支座上，   
5 针刺性能 不爆炸、不起火  并与热电偶相连，然后用直径为3mm的铁钉在电池的   
  最高温度≤130oC  高度方向中间的部位快速完全刺穿电池，观察电池外   
    观及温度变化。   
    电池标准充电后，测量电池的初始状态，放在平面上，   
6 重物冲击 不爆炸、不起火  并与热电偶相连，然后用直径为3mm的铁钉在电池的   
 性能   表面   
 压缩安全   测量电池的初始状态，电池标准充电后，与热电偶相   
7 性能 不起火，不爆炸  联，放置          
8 热冲击安   测量电池的初始状态，电池标准充电后，与热电偶相          
 全性能 不起火，不爆炸  连，温度以（5±2oC）/min的速率升至150±2oC并保          
    温10Min。观察电池外观变化          
   深圳市聚力电池有限公司           
              
产品规格书    文件编号 No.  日期： Rev       
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18        
4.3环境适应性能              
注意：如果进行下述试验，均须在良好的安全措施保护下，有专业人员进行。否则可能会对试验设备              
 和人身造成意外伤害！！！              
序号 项目 标准  测试方法          
1 热循环 不冒烟、不起火  电池标准充电后，在环境温度为75oC的条件下开路          
 性能 不爆炸  放置48h，后在-20oC条件下开路放置6h，后在室温条件          
    下开路放置24h，然后0.5C5A进行放电至2.75.以          
    0.5C/0.5C连续做3次充放电循环。          
2 恒定湿热 搁置后放电容量/标称容量  电池标准充电后，在环境温度为40±5oC，相对湿度   
 性能 *100%≥60%  为95±2%的恒定恒湿箱中，搁置168h后，取出电池   
    搁置2h，以0.5C5A放电至2.75V。   
    测试电池的初始容量，标准充电后，测量电池的初始   
3 跌落性能 电池不冒烟、不起火、  状态，将电池样品由高度（最低点高度）为1.2m的位   
  不爆炸  置从XYZ正负6个方向自由跌落在木板上。跌落完成后   
    测量电池的最终状态。   
4 不同温度 放电容量/标称容量*100%  测量电池的初始状态，电池标准充电后，在60±2oC   
 下的放电 A）60oC≥95%  条件下恒温搁置3h、以0.2C5A放电至2.75V，然后在室   
 性能 B）0oC≥85%  温条件下标准充电，依次0oC、-10oC、-20oC在相应   
  C）-10oC≥70  恒温条件下搁置20h，以0.2C5A测量终止容量，然后   
  D）-20oC≥60%  在室温状态下搁置2h测量最终状态，观察电池外观变   
  不冒烟、不起火、不爆炸  化。   
    测量电池的初始容量。电池标准充电后，测量电池   
 振动环境   初始状态，电池充电后，安装在振动台上，按下面   
5 适应性能   的震动频率和对应的震幅调整好试验设备，X、Y、Z、   
  剩余容量》标称容量*95%  三个方向每个方向从10Hz~55Hz循环扫频震动30Min，                                                                                                                                                                                                                                                           
  电池外观无明显损伤、不冒  扫频速率为10Ct/Min:                                                                                                                                                                                                                                                           
  烟、不爆炸  A）振动频率：10Hz~30Hz位移幅值（单振幅）0.38mm                                                                                                                                                                                                                                                           
    B）振动频率：30Hz~50Hz位移幅值（单振幅）0.19mm                                                                                                                                                                                                                                                           
    扫频结束后测量电池的最终状态以及电池最终容量。                                                                                                                                                                                                                                                           
                                                                                                                                                                                                                                                               
   深圳市聚力电池有限公司                                                                                                                                                                                                                                                            
                                                                                                                                                                                                                                                               
产品规格书    文件编号 No.  日期： Rev                                                                                                                                                                                                                                                        
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18                                                                                                                                                                                                                                                         
5.0 保质期及产品责任                                                                                                                                                                                                                                                               
     保质期是从出厂日期（按照喷码日期）开始起12个月                                                                                                                                                                                                                                                               
     博力康公司对于没有按照规格书操作导致的问题不负责任，保留对规格书在没有预先通知的前提下                                                                                                                                                                                                                                                               
变更的权利。                                                                                                                                                                                                                                                               
6.0 包装电池上的标识                                                                                                                                                                                                                                                               
       ● 一般情况下电池标识由产品型号、正负极、电压、容量以及出厂日期构成。                                                                                                                                                                                                                                                               
       ●   客户有指定时候可加上客户指定标志       
       ●  保质期限：自出厂之日起12个月内。       
7.0 电池使用时警告事项以及注意事项       
     为防止电池可能发生泄漏，发热，爆炸，请注意以下预防措施：       
     ● 严禁将电池浸入海水或水中，保存不用时，应放置在阴凉干燥的环境中。       
     ● 禁止将电池在热高温源旁，如火，加热器等使用和留置。       
     ● 充电时请选用锂离子电池专用充电器。       
     ● 严禁颠倒正负极使用电池。       
     ● 严禁将电池直接接入电源插座。       
     ● 禁止将电池丢入火或加热器中       
     ● 禁止用金属直接连接电池正负极短路。       
     ● 禁止将电池与金属，如发夹，项链等一起运输或贮存。       
     ● 禁止敲击或抛掷，踩踏电池等。       
     ● 禁止直接焊接电池和用钉子或其它利器刺穿电池。       
      注意事项：       
    ◆ 禁止在高温下（直热的阳光下或很热的汽车中）使用或放置电池，否则可能会引起 电池过       
       热，起火或功能失效，寿命减短。                                                                                                                                                                                                                                                               
    ◆ 禁止在强静电和强磁场的地方使用，否则易破坏电池安全保护装置，带来不安全的隐患。                                                                                                                                                                                                                                                               
    ◆ 如果电池发生泄漏，电解液进入眼睛，请不要揉擦，应用清水冲洗眼睛，并立即送医治疗，                                                                                                                                                                                                                                                               
         否则会伤害眼睛。                                                                                                                                                                                                                                                               
    ◆ 如果电池发出异味，发热，变色，变形或使用，贮存，充电过程中出现任何异常现象，                                                                                                                                                                                                                                                               
        立即将电池从装置或充电器中移离并停用。                                                                                                                                                                                                                                                               
   深圳市聚力电池有限公司                                                                                                                                                                                                                                                            
                                                                                                                                                                                                                                                               
产品规格书    文件编号 No.  日期： Rev                                                                                                                                                                                                                                                        
锂离子电池  LC 32600  5000mAh    JooLee100418  2010-4-18                                                                                                                                                                                                                                                         
                                                                                                                                                                                                                                                               
                                                                                                                                                                                                                                                               
     ◆ 如果电池弄脏，使用前应用干布抹净，否则可能会导致接触不良功能失效。                                                                                                                                                                                                                                                               
     ◆ 废弃之电池应用绝缘纸包住电极，以防起火，爆炸。                                                                                                                                                                                                                                                               
                                                                                                                                                                                                                                                               
                                                                                                                                                                                                                                                               
如有疑问，请按以下地址联系：       
        深圳市聚力电池有限公司       
        地址：深圳市宝安区大浪云峰路3号       
        电话：0755-61596372  61596373       
        传真：0755-29080110       
        邮箱：joolee@joolee.com.cn